Storm collars
Collars and caps are checked and replaced as needed to keep out animals and rain.
Chimney Parts
Chase Cover Replacement Farmingdale, NJ
A chimney sweep in Farmingdale can replace the metal cover on top of a framed chimney chase sized to the chase and shaped to shed water off the edges. Dial (732) 835-0018 to talk with a local chimney pro about your chase.
If your chimney is covered in siding instead of brick, it is probably a chase built around a metal flue. The chase cover, sometimes called a chase top or chase pan, is the metal sheet that caps the top of that enclosure. Its job is to keep water out of the framing and away from the fireplace below.
Builder grade chase covers are usually galvanized steel cut flat across the top. A flat galvanized pan collects water, rusts through and stains the siding below. Rust running down the chase is usually the first clue.
Water that gets past the cover can do real damage inside the chase. Rotted framing, wet insulation, rusted firebox parts and water stains inside the house are all common results. Catching a bad cover early keeps the repair simple.
Many chase cover replacement calls in Farmingdale also turn up a need for chimney cap installation or chimney leak repair.
Need chase cover replacement in Farmingdale? Call (732) 835-0018 to talk to a local chimney sweep.
Call nowThe process
The chase cover replacement process
Here is how a sweep usually handles a chase cover replacement.
Look for damage
The condition of the cover, collar and chase top is checked. Any rot in the framing is noted.
Take measurements
Exact measurements are taken so the new cover fits snugly. A good fit matters more than anything else.
Take off the old top
The old chase top is removed, along with any rusted fasteners. This is the best time to look for rot.
Install the new cover
A sloped stainless or copper cover is fitted and fastened through the side skirt. Screws go through the sides so the top stays watertight.
Reinstall the cap
A sealed storm collar and cap close up the opening at the flue. The sweep makes sure water has nowhere to get in.
What is included
What chase cover replacement covers
Drip edges
The edge of the cover is bent so water drips clear of the chase which protects trim and siding.
Stainless covers
Stainless steel is the most common replacement material without needing paint.
Sloped tops
Covers are made with a slope, cross break or raised center so water runs off and keep the cover drier.
Copper chase covers
A copper chase top adds a finished look and resists corrosion for homes where looks matter.
Related service
Chimney Chase Repair Farmingdale, NJ
Chase repair goes hand in hand with replacing a cover that has been leaking. The work may include new framing, new sheathing, siding repairs and drying or replacing insulation. The framed chase also needs proper flashing where it meets the roof.
When you call (732) 835-0018 from Farmingdale, mention where you have seen water or rust, since it helps locate the leak. Bigger framing repairs may involve a carpenter, while the cover and cap are handled by the sweep. The new cover should go on a sound chase.
Local help
Chase Cover Replacement Near Me
In Farmingdale, many newer homes have prefab fireplaces with chimney chases and builder grade chase tops. Homes in Farmingdale and nearby towns such as Ramtown, Tinton Falls, Shark River Hills and East Freehold often have chase covers that were installed when the house was built and never replaced, and a sloped stainless or copper cover usually ends the problem.
Need chase cover replacement around Farmingdale? Call (732) 835-0018 for a Farmingdale chimney sweep who serves the towns around it too.
What the local climate does to a chimney
Cold winters keep fireplaces, wood stoves and oil burners working for half the year or more. Masonry takes the worst of it from the freeze and thaw cycle: rain and melting snow soak into the crown and joints, then freeze and push them apart, and each winter widens the cracks a little more. Nor'easters drive rain sideways into flashing and mortar that looked fine in summer. Most homeowners in Farmingdale, NJ schedule a sweep in early fall, and a repair check after a hard winter.
Why call
Why act early
Safer fires
A chimney problem fixed early rarely spreads to the masonry, the liner or the house.
Local knowledge
Chimney sweeps in Farmingdale know the chimneys and fireplaces common in local homes.
Clear next steps
Ask the sweep about the cause, the options and the estimate before work starts.
Chase Cover Replacement questions
What is a chase cover?
A chase cover is the metal top on a framed chimney chase, the boxed enclosure around a factory-built chimney pipe. Without it, water would run straight into the chase. A cap sits on top of the flue pipe that comes through the cover.
How long will a new chase cover hold up?
Quality covers in stainless or copper hold up for a long time. A sloped design and drip edge help it last by keeping water moving. Have it checked during chimney sweeping.
Why is there water in my prefab fireplace?
Water from a leaking chase cover often runs down the flue pipe or framing and into the fireplace. It can lead to rust, damaged panels and stains around the fireplace. The sweep will check the cover, collar and cap to find the source.
Should I patch or replace my chase cover?
Small holes can sometimes be patched, but patches on a rusting galvanized cover rarely last. Replacing it with a sloped stainless or copper cover is the more lasting fix. Ask the sweep to check the framing under the cover too.
Why are there rust streaks on my chimney siding?
Builder grade chase tops are often galvanized steel, and they rust after years of weather. Water pooling on a flat cover speeds up corrosion. That rust washes down and stains the siding below.
More questions? Call (732) 835-0018
Other services that may help
Chimney Cap Installation
Putting a sturdy cap on top of the chimney so water, birds and debris stay out of the flue.
Learn moreChimney Leak Repair
Tracing chimney leaks to the real entry point and sealing it, before the water rots framing or ruins the flue.
Learn moreChimney Waterproofing
Treating chimney brick and mortar with a breathable water repellent, to slow freeze-thaw damage and spalling.
Learn moreChimney Repair
Chimney repairs from the cap and crown down to the firebox, matched to what an inspection actually finds.
Learn more
Looking for something else?
See all chimney servicesNeed chase cover replacement in Farmingdale, NJ?
Call (732) 835-0018 for a local chimney sweep in Farmingdale and nearby towns.
(732) 835-0018
Free to call. No forms to fill out.